Performance Evaluation of a Combined Heat and Power Plant in the Niger Delta of Nigeria

##plugins.themes.bootstrap3.article.main##

  •   Barikuura Gbonee

  •   Barinyima Nkoi

  •   John Sodiki

Abstract

This research presents the performance assessment of a combined heat and power plant operating in the Niger Delta region of Nigeria. The main focus is to evaluate the performance parameters of the gas turbine unit and the waste heat recovery generator section of the combined-heat-and-power plant. Data were gathered from the manufacturer’s manual, field and panel operator’s log sheets and the human machine interface (HMI) monitoring screen. The standard thermodynamic equations were used to determine the appropriate parameters of the various components of the gas turbine power plant as well as that of the heat exchangers of the heat recovery steam generator (HRSG). The outcome of all analysis indicated that for every 10C rise in ambient temperature of the compressor air intake there is an average of 0.146MW drop in the gas turbine power output, a fall of about 0.176% in the thermal efficiency of the plant, a decrease of about 2.46% in the combined-cycle thermal efficiency and an increase of about 0.0323 Kg/Kwh in specific fuel consumption of the plant. In evaluating the performance of the Waste Heat Boiler (WHB), the principle of heat balance above pinch was applied to a single steam pressure HRSG exhaust gas/steam temperature profile versus exhaust heat flow. Hence, the evaporative capacity (steam flow) of the HRSG was computed from the total heat transfer in the super-heaters and evaporator tubes using heat balance above pinch. The analysis revealed that the equivalent evaporation, evaporative capacity (steam flow) and the HRSG thermal efficiency depends on the heat exchanger’s heat load and its effective maintenance.


Keywords: Combined-Heat-and-Power, Thermal Efficiency, Steam Flow, Heat Absorption, Specific Fuel Consumption.

References

Culp, A. W. (JR), (1979). Principles of Energy Conversion, McGraw-Hill.

Yadav, R. (2009). Steam & Gas Turbine and Power Plant Engineering Central Publishing House, Allahabab.

Cengel, Y. A. Turner, R. H & Cimbala, J. M (2008). Fundamentals of Thermal-Fluid Science. Published by McGraw-Hill Companies, Inc. 1221 Avenue of the Americas, New York, NY 10020.

Nag, P. k. (2013). Power Plant Engineering, 3rd Edition, New Delhi; India, Tata McGraw-Hill Education Private Limited.C. Y. Lin, M. Wu, J. A. Bloom, I. J. Cox, and M. Miller, “Rotation, scale, and translation resilient public watermarking for images,” IEEE Trans. Image Process., vol. 10, no. 5, pp. 767-782, May 2001.

Nkoi, B & Lebele-Alawa, B. T. (2015). Comparative Assessment of combined-Heat-and-Power performance of Small-Scale Aero-Derivative Gas Turbine Cycles. Journal of Power and Energy Engineering, 3.20-32. http://dx.doi.org/10.4236 /ipee.2015.39002.

Perry, R. H, & Green, D. (1998). Chemical Engineers Hand Book. U.S.A, 7th ed, McGraw-Hill Book Company.

Walsh, P. P, & Fetcher, P. (2010). Gas turbine performance, 2nd Edition, Blackwell Publishing. Wiley India PVT. Ltd.

Hart, H. I. (1998). Thermodynamic Appraisal of Niger Delta Gas Turbine Performance. PhD’s Thesis, Mechanical Engineering. University of Nigeria, Nsukka, Nigeria.

Rahman, M. M, Thamir, K. I, & Ahmed, N. A. (2011). Thermodynamic Performance Analysis of Gas Turbine Power Plant www.academic journals. Org/article/article 1380722812- rahman %20 et % 20 al. pdf.

Boonasa, S., Namprakai, P. & Muangnapoh, T. (2006). Performance Improvement of the combined cycle power plant by intake air cooling using an absorption chiller. Energy, 31(12).

Chattopadhyay, P. (2001). Boiler Operation Engineering Question and Answers. 2nd Edition, McGraw-Hill Companies, Inc. U.S.A.

Mitsubishi, (1985). National Fertilizer Company of Nigeria Ltd. Nitrogenous Fertilizer Project, Rivers State. Operation and Maintenance Manual. Model: MW -251, serial No. T- 206. Customer job No. 6348-50, Vol. M-1.

Downloads

Download data is not yet available.

##plugins.themes.bootstrap3.article.details##

How to Cite
[1]
Gbonee, B., Nkoi, B. and Sodiki, J. 2019. Performance Evaluation of a Combined Heat and Power Plant in the Niger Delta of Nigeria. European Journal of Engineering Research and Science. 4, 4 (Apr. 2019), 17-23. DOI:https://doi.org/10.24018/ejers.2019.4.4.1055.